How To Repair Awning Motor

To repair a tear in your rv awning you will need to purchase a roll of clear rv awning repair tape.

How to repair awning motor.

This told me the motor and wiring to the awning was good. If it did show 12 v then that means the awning wiring is fine and the issue lies with the motor. These rolls typically run around 15 00 and are 15 feet in length. Solera awning motor wires.

Secure everything using a few tie downs and stakes. However diy awnings helps make shading solutions more affordable for all homeowners by providing a way to do the awning installation or repairs yourself. I disassembled the control panel and swapped the slide out room switch it uses the same switch with the power awning switch and the fault swapped as well. Use silicone spray to keep the metal tension arms knobs and legs from rusting or locking into place.

I tried the awning using it and it worked. Use an awning deflapper to add tension to the awning in the middle preventing wind damage and tears. By doing this the motor should start to operate and extend or retract the awning. Repairing the rv awning power switch.

Use vinyl cleaner often to keep it spotless and free of mildew. Locate the supply connection terminal on the motor and connect it with the battery supply wires that you will have. You should have directions in your owner s manual on how to manually override the system and bring the awning back in. Don t use any other type of tape as this can damage the awning.

Remove the bad motor and replace it with the new one. Rub down the rails pulley rollers and retracting arm to make sure they are not sticking due to friction rust or dirt. Pull the wires up to access the quick disconnects and unplug the motor. Typically it s removing one or two screws near the motor and rolling it by hand with two people.

It s true that having a professional install or repair your awning can be costly. Remove the 3 bolts that hold the motor in place using a 10mm wrench or socket. Remove the front and back covers from the motor on the right side of the awning. You can find this tape at any store that sells camping supplies or at your rv dealer.

You can splice a broken awning tube or replace the awning tube but be sure t.